Material Safety Data Sheet for Product Number 16010 - Stainless Steel Ball Texpen - Blue - #0 Tip
ITW Mark-Tex
565 Eagle Rock Ave
Roseland, NJ 07068
Phone: (800) 222-0876
(973) 403-9890
Chemtrex: (800) 262-8200
www.dykem.com/msds
Product Identification:
PRODUCT NAME: CA Blue
OTHER NAMES: J2143
HMIS:
HEALTH: 2
FLAMMABILITY: 3
REACTIVITY: 0
PERS PROTECTION: C
Shipping Information:
UN ID
UN 1263
DOT SHIPPING NAME (CLASS): PAINT (3)
Containers <1 Pint is ORM-D
WHMIS (CANADA ONLY) B3
PACKING GROUP: II
Hazardous Ingredient(s):
Information on this Material Safety Data Sheets refers to inks or paints used in pens and markers; however, it applies to these inks or paints in bulk. The
inks or paints are contained in capillary or valve reservoirs and will not spill or lead under normal conditions.
INGREDIENT
CAS REG. NUM
% WEIGHT
THRESHOLD LIMIT VALUE
AROMATIC HYDROCARBON
64742-95-6
32
100 PPM/8 HRS PEL
CLAY, SILICA
1332-58-7
26
15 mg/M
3
*
TITANIUM DIOXIDE
13463-67-7
6
15 mg/ M
3
*
HYDROCARBON RESIN
68240-01-7
20
10 mg/ M
3
*
PCN BLUE
147-14-8
3
10 mg/ M
3
*
HYDROCARBON RESIN
9003-55-8
11
10 PPM TLV*
This product is in compliance with the EPA TSCA Inventory.
Physical Data:
BOILING POINT: LOW: 350
o
F (177
o
C) HIGH: 410
o
F
SPECIFIC GRAVITY: >1.0
% VOLATILE BY VOLUME: 40
SOLUBILITY IN WATER: NIL
APPEARANCE: Thick Liquid with Aromatic Odor
(210
o
C)
VISCOSITY: 3000-4000 CPS
VAPOR DENSITY: 4.8
VOC: 3.1 LBS/GAL
VAPOR PRESSURE: 3 mm Hg @ 25
o
C
EVAPORATION RATE: Slower than Ether
Fire and Explosion Data:
FLASH POINT: 112
o
F TCC
LEL: 0.01
UEL: 0.07
EXTINGUISHING MEDIA: Foam, CO
2
, Dry Chemical, and Water Spray
UNUSUAL HAZARDS: NA
SPECIAL PROCEDURES: NNR
Health Hazard Data:
LISTED AS POSSILE CARCINOGEN -
NPT: NL
IARC: NL
OSHA: NL
IF YES:
SYMPTOMS OF OVEREXPOSURE: Headache, Dizziness, Nausea, Anesthesia, Coughing, Eye, Throat, and Irritation
EFFECTS OF OVEREXPOSURE: Slight to Severe Irritation to eyes and mucous membranes of nose and throat. Dermatitis. Affects central nervous
PRIMARY ROUTES OF ENTRY: Ingestion, Dermal or Inhalation
EMERGENCY FIRST AID: Inhalation; Seek fresh air. Give artificial respiration if not breathing. Skin contact; Wash with copious water. Ingestion;
Reactivity Data:
STABILITY: Stable
HAZARDOUS POLYMERIZATION:
WILL NOT OCCUR
CONDITIONS TO AVOID: Heat, Open Flames, and Sparks
INCOMPATABILITY:
Do not mix with strong oxidants
HAZARDOUS DECOMPOSITION: Carbon Monoxide, Carbon Dioxide, and unidentified organic combustion products
Environmental Protection Procedures:
SPILL RESPONSE: Remove all ignition sources, ventilate area, and use absorbent material to clean spill.
DISPOSAL METHODS: Dispose of waste in accordance with local and federal regulations.
PROTECTIVE GEAR: NNR
ADDITIONAL MEASURES: Keep away from heat, fire, and strong oxidants. Store in cool place (room temperature). Use adequate ventilation.
SPECIAL PRECAUTIONS: NA
* Free dust, not bound in paint/ink matrix.
NA = Not Applicable, NL = Not Listed, NNR = Not Normally Required, NE = Not Established
REVISION: JC-10/99
ADDITIONAL INFORMATION:
1
